Carrera, P., Campo, R., Mendez, R., Di Bella, G., Campos, J. L., Mosquera-Corral, A., et al. (2019). Does the feeding strategy enhance the aerobic granular sludge stability treating saline effluents? Chemosphere, 226, 865–873.
Abstract: The development and stability of aerobic granular sludge (AGS) was studied in two Sequencing Batch Reactors (SBRs) treating fish canning wastewater. R1 cycle comprised a fully aerobic reaction phase, while R2 cycle included a plug-flow anaerobic feeding/reaction followed by an aerobic reaction phase. The performance of the AGS reactors was compared treating the same effluents with variable salt concentrations (4.97-13.45 g NaCl/L) and organic loading rates (OLR, 1.80-6.65 kg CODs/(m(3).d)). Granulation process was faster in R2 (day 34) than in R1 (day 90), however the granular biomass formed in the fully aerobic configuration was more stable to the variable feeding composition. Thus, in R1 solid retention times (SRT), up to 15.2 days, longer than in R2, up to 5.8 days, were achieved. These long SRT5 values helped the retention of nitrifying organisms and provoked the increase of the nitrogen removal efficiency to 80% in R1 while it was approximately of 40% in R2. However, the presence of an anaerobic feeding/reaction phase increased the organic matter removal efficiency in R2 (80-90%) which was higher than in R1 with a fully aerobic phase (75-85%). Furthermore, in R2 glycogen-accumulating organisms (GAOs) dominated inside the granules instead of phosphorous-accumulating organisms (PADS), suggesting that GAOs resist better the stressful conditions of a variable and high-saline influent. In terms of AGS properties an anaerobic feeding/reaction phase is not beneficial, however it enables the production of a better quality effluent. (C) 2019 Elsevier Ltd. All rights reserved.
|
del Rio, A. V., Stachurski, A., Mendez, R., Campos, J. L., Surmacz-Gorska, J., & Mosquera-Corral, A. (2017). Short- and long-term orange dye effects on ammonium oxidizing and anammox bacteria activities. Water Sci. Technol., 76(1), 79–86.
Abstract: The effects of orange azo dye over ammonia oxidizing bacteria (AOB) and anammox bacteria activities were tested. Performed batch tests indicated that concentrations lower than 650 mg(orange)/L stimulated AOB activity, while anammox bacteria activity was inhibited at concentrations higher than 25 mg(orange)/L. Long-term performance of a continuous stirred tank reactor (CSTR) for the partial nitritation and a sequencing batch reactor (SBR) for the anammox process was tested in the presence of 50 mg(orange)/L. In the case of the partial nitritation process, both the biomass concentration and the specific AOB activity increased after 50 days of orange azo dye addition. Regarding the anammox process, specific activity decreased down to 58% after 12 days of operation with continuous feeding of 50 mg(orange)/L. However, the anammox activity was completely recovered only 54 days after stopping the dye addition in the feeding. Once the biomass was saturated the azo dye adsorption onto the biomass was insignificant in the CSTR for the partial nitritation process fed with 50 mg(orange)/L. However, in the SBR the absorption was determined as 6.4 mg(orange)/g volatile suspended solids. No biological decolorization was observed in both processes.
|
Morales, N., del Rio, A. V., Vazquez-Padin, J. R., Mendez, R., Campos, J. L., & Mosquera-Corral, A. (2016). The granular biomass properties and the acclimation period affect the partial nitritation/anammox process stability at a low temperature and ammonium concentration. Process Biochem., 51(12), 2134–2142.
Abstract: Extensive research on the anammox-based processes under mainstream conditions is currently in progress. Most studies have used a long acclimation period for the partial nitritation-anammox (PN-An) sludge at a low temperature and ammonium concentration. However, in this study, the results demonstrated that PN-An granular biomass produced under sidestream conditions (30 degrees C and 1000 mg NH4+-N/L) can operate at 15 degrees C and 50 mg NH4+-N/L without acclimation. The nitrogen removal efficiency was 70% and was stable for 60 days. The long-termoperation of the system with progressive adaptation provided important information for process optimization. Control of the dissolved oxygen (DO) concentration was crucial to maintain the balance between ammonia oxidizing bacteria (AOB) and anammox bacteria activities. A calculation of the oxygen penetration depth inside the granules is proposed to estimate an adequate DO level, which allows for the definition of the aerobic and anoxic zones that depend on the temperature, the size distribution and the granule density. However, the development of NOB was difficult to avoid with DO control alone. The selective washing-out of the floccular biomass, which contains mainly NOB, is proposed, leaving the granular fraction with the AOB and anammox bacteria in the system. (C) 2016 Published by Elsevier Ltd.
|
Pedrouso, A., Morales, N., Rodelas, B., Correa-Galeote, D., del Rio, A. V., Campos, J. L., et al. (2023). Rapid start-up and stable maintenance of the mainstream nitritation process based on the accumulation of free nitrous acid in a pilot-scale two-stage nitritation-anammox system. Sep. Purif. Technol., 317, 123851.
Abstract: Two-stage partial nitritation (PN) and anammox (AMX) systems showed promising results for applying auto-trophic nitrogen removal under mainstream conditions. In this study, a pilot-scale (600 L per reactor) two-stage PN/AMX system was installed in a municipal wastewater treatment plant (WWTP) provided with a high-rate activated sludge (HRAS) system for organic carbon removal. The PN/AMX system was operated without tem-perature control (ranging from 11 to 28 degrees C) and was subjected to the same variations in wastewater charac-teristics as the WWTP (22 to 63 mg NH4+- N/L). The developed strategy is simple, does not require the addition of chemicals and is characterised by short start-up periods. The PN process was established by applying a high hydraulic load and maintained by in situ accumulated free nitrous acid (FNA) of 0.015-0.2 mg HNO2-N/L. Based on pH value, a controlled aeration strategy was applied to achieve the target nitrite to ammonium ratio in the effluent (1.1 g NO2--N/g NH4+-N) to feed the AMX reactor. Although NOB were not fully washed out from the system, nitrite accumulation remained (>99 %) stable with no evidence of NOB activity. In the AMX reactor, an overall nitrogen removal efficiency of 80 % was achieved. Regarding effluent quality, 12 +/- 3 mg TN/L was obtained, but 5 mg NO3--N/L was already in the HRAS effluent. The relative abundance of NOB showed a strong negative correlation with the FNA concentration, providing a good strategy for establishing PN under main-stream conditions.
|
